Rongsheng Mud pump parts list
| RS-F1600/1300 MUD PUMP | ||
| PARTS LIST FOR RS-F1600/1300 MUD PUMP | ||
| Assembly drawing | RS11306.00 | |
| Pinion shaft assembly | RS11306.03.00 | |
| Crank shaft assembly | RS11306.02.00 | |
| Splash lubricating system of power end | RS11306.06.00 | |
| Crosshead assembly | RS11306.04.00 | |
| Fluid end assembly | RS11306.05.00 | |
| Discharge bent pipe assembly | RS11306.20A.00 | |
| Discharge filter screen assembly | RS11306.21.00 | |
| Discharge pulsation bladder | RS11305.10.00 | |
| Spray pump | RS11305.14.00 | |
| 1 | RS11309.01.00 | Frame assy. |
| 2 | RS11309.02.00(F1600) | Crankshaft assy.- |
| RS11310.01.00(F1300) | Crankshaft assy.- | |
| 3 | RS11309.03.00(F1600) | Pinion shaft assy.- |
| RS11310.02.00(F1300) | Pinion shaft assy.- | |
| 4 | RS11309.04.00 | Crosshead assy. |
| RS11309.05.00 | Fluid End assy. | |
| 6 | RS11309.06.00 | Power End lubrication system |
| 7 | RS11309.07.00 | Base |
| 8 | RS11309.08.00 | Spray pump assy. |
| 9 | RS11309.009 | Pack washer |
| 10 | RS11306.11.00 | Vent cover |
| 11 | RS11310.003 | RS nameplate |
| 12 | GB818 | Screw M4x16 |
| 13 | RS11309.11.00 | Small crane |
| 14 | RS11309.12.00 | mast-up |
| 15 | RS11309.021 | Back cover piate |
| 16 | RS11306.13.00 | Pack washer |
| 17 | RS11306.014 | Indicator |
| 18 | GB827 | Screw 3X10 |
| 19 | RS11306.15.00 | Oil indicator assy. |
| 20 | RS11306.18.00 | Discharge cover |
| 21 | RS11310.004 | Hole cover.crosshead |
| 22 | RS11309.14.00 | Washer |
| 23 | RS11309.15.00 | cover plate assy. |
| 24 | Adjust washer | |
| 25 | B.005 | Bolt 1/16-8UNX15 |
| 26 | N.003 | Nut l 1/16-8UN-2B |
| 27 | GB93 | Spring washer 21 |
| 28 | B.05.016 | Bolt1-8UNCX4 |
| 29 | N.001 | Nut1-8UNC-2B |
| 30 | GB93 | Sprinq washer24 |
| 31 | B.001 | Bolt 1/2-13UNCx1 |
| 32 | GB848 | Washer 12 |
| 33 | Rubber strip 40X10X5800 | |
| 34 | B.004 | Bolt 5/8-11UNCX2 3/8 |
| 35 | N.002 | Nut5/8-1W-2B |
| Spring washer 16 | ||
| 37 | B.003 | Bolt5/8-11UNCX15/ |
| 38 | RS11306.19.00 | KB-75 pulsation dampener |
| 39 | YK-150 | Shock resistance gauge 60MPa ZG101/2 |
| 40 | RS11309.16.00 | Discharge way spool |
| JA-3 Safety valve | ||
| 42 | RS11309.17.00 | Connect pipe. safety valve |
| 43 | SY5279.3-91 | Gasket ring R44 |
| 44 | RS11309.18.00 | 5-way spool support |
| Anaerobic oxyen glue for screw | ||
| RS-F1600/1300 Part list of Crank assembly | ||
| l | RS11309.02.001 | Main bearing end cover |
| 2 | RS11309.02.002(F1600) | right bearing sleeve |
| RS11310.01.001(F1300) | ||
| 3 | RS11309.02.003 | washer |
| 4 | RS11309.02.004 | inner closing ring |
| 5 | RS11309.02.05.00(F1600) | out dosing ring |
| RS11309.01.002(F1300) | out dosing ring | |
| 6 | RS11309.02.006(F1600) | pitman |
| RS11309.01.003(F1300) | out dosing ring | |
| 7 | RS11309.02.007 | steady ring 1 |
| 8 | RS11309.02.08.00 | crank |
| 9 | RS11309.02.009 | steady ring II |
| 10 | RS11309.02.010(F1600) | big gear rim |
| RS11310.01.004(F1300) | big gear rim | |
| 11 | B02.006 | bolt 1 1/2-8UNCx5.25 |
| 12 | RS11309.02.011 | spacer ring |
| 13 | RS11309.02.012(F1600) | left bearing sleeve |
| RS11310.01.005(F1300) | left bearing sleeve | |
| 14 | RS11309.02.013(F1600) | Retainer ring |
| RS11310.01.006(F1300) | Retainer ring | |
| 15 | RS11309.02.014 | baffle |
| 16 | RS11309.02.015 | main bear bolt |
| 17 | RS11309.02.016 | wahser |
| 18 | B02.07 | bolt 5/8-11uncx4.75 |
| 19 | RS11306.05.15.00 | Nut 1 1/2-8unc |
| 20 | B02.002 | bolt 5/8-1Iuncx15 |
| 21 | RS11309.02.017(F1600) | eccentricity wheel bearing |
| RS11310.01.007(F1600) | eccentricity wheel bearing | |
| 22 | RS11309.02.018(F1600) | Main bearing |
| RS11310.01.008(F1300) | Main bearing | |
| 23 | B02.004 | screw 5/8-11UNCx4 |
| 24 | B02.003 | bolt 5/*-11UNCx1.75 |
| 25 | GB848 | washer 16 |
| 26 | GB343 | locking wire 1.5 |
| 27 | GB343 | locking wire 3 |
| 28 | 242 | AnoEROBIC Oxygen glue for screw |
| RS-F1600/1300 Small gear shaft assembly Part list of Small gear shaft assembly | ||
| 1 | RS11309.03.001 | Flat KEY |
| 2 | RS11309.03.002(F1600) | pinion shaft |
| RS11310.02.001(F1300) | pinion shaft | |
| 3 | RS11309.03.003 | antifriction sleeve |
| 4 | RS11309.03.004 | End cover |
| 5 | RS11309.03.005 | sealing wahser |
| 6 | RS11309.03.006 | sealing wahser |
| 7 | RS11309.03.007 | bearing sleeve |
| 8 | RS11309.03.008 | retainer ring |
| 9 | RS11309.03.009 | sealing wahser |
| 10 | RS11309.03.10.00 | Accumulator tray |
| 11 | RS11309.03.011 | oil seal |
| 12 | RS11309.03.012 | bearing 4G32844H |
| 13 | RS11309.03.013 | Flange |
| 14 | B03.002 | bolt 1/2-13UNC x 1 3/8 |
| 15 | B03.003 | bolt 7/8-9UNCx2 |
| 16 | GB93 | spring washer 22 |
| 17 | GB93 | Spring wahser 12 |
| 18 | B02.002 | Bolt 5/8-11uncX 1 3/4 |
| 19 | GB93 | spring washer16 |
| Part list of Crosshead assembly | ||
| 1 | RS11309.04.001 | crosshead |
| 2 | RS11309.04.002 | Top guiding plate |
| 3 | RS11309.04.003 | washer |
| 4 | RS11309.04.004 | adjust washer |
| 5 | RS11309.04.005 | Filling box |
| 6 | RS11309.04.006 | oii-seai ring |
| 7 | RS11309.04.007 | oil seal |
| 8 | RS11309.04.008 | lock spring |
| 9 | RS11309.04.009 | Mudquard |
| 10 | RS11309.04.010 | internediate rod |
| 11 | RS11309.04.011 | cross head pin |
| 12 | RS11309.04.012 | seal washer |
| 13 | RS11309.04.013 | bottom guiding piate |
| 14 | RS11309.04.014 | baffle |
| 15 | RS11309.04.015 | cross head bear |
| 16 | RS11306.041004 | joint NPT3/8 |
| 17 | B04.003 | bolt 1-8UNCX2 1/4 |
| 18 | B04.002 | bolt 1-8UNCX2 1/2 |
| 19 | RS11306.04.009 | fixed plate |
| 20 | B04.004 | screwl-8UNCX2.5 |
| 21 | GB4240 | lock steel wire |
| 22 | GB34521 | O ring 125X7 |
| 23 | GB34521 | O ring 160X7 |
| 24 | GB34521 | O ring 190X3.55 |
| 25 | B04.005 | bolt 3/8-16UNCX1 |
| 26 | GB93 | spring washer 10 |
| 27 | B04.006 | bolt 3/4-10UNCX2.5 |
| 28 | 242 glue | sealing glue |
| Part list of Fluid end assembly | ||
| 1 | RS11309.05.01.00 | [vUnder |
| 2 | RS11309.05.002 | flange |
| 3 | RS11309.05.003 | cylinder cover |
| 4 | RS11309.05.04.00 | inserter |
| 5 | RS11309.05.05.00 | guiding device |
| 6 | RS11309.05.06.00 | pluq |
| 7 | RS11309.05.007 | locating plate |
| 8 | RS11309.05.008 | seaiinq rinq |
| 9 | RS11309.05.009 | discharge pipe |
| 10 | RS11306.05.013 | spring |
| 11 | RS11309.05.10.00 | valve Assen. |
| 12 | RS11309.05.011 | sealing ring |
| 13 | RS11309.05.012 | vaive 匚over |
| 14 | RS11309.05.013 | sealing ring |
| 15 | RS11309.05.014 | wear plate |
| 16 | RS11309.05.015 | fianqe |
| 17 | RS11309.05.016 | end cover |
| 18 | RS11309.05.017 | Piston rod |
| 19 | RS11309.05.18.00 | snrav nine |
| 20 | RS11309.05.019 | iockinq rinq |
| 21 | RS11309.05.020 | cylinder sleeve |
| 22 | RS11309.05.021 | clip assy. |
| 23 | RS11309.05.022 | end 匚ovpr |
| 24 | RS11309.05.023 | piston |
| 25 | RS11309.05.024 | suck pipe |
| 26 | RS11309.05.025 | washer |
| 27 | RS11306.05.010 | guiding device(upper) |
| 28 | B05.010 | bolil 1/P-8UNX10 3/8 |
| 29 | RS11309.05.026 | baffle |
| 30 | B05.002 | bolt 3/8-16UNCX3/4 |
| 31 | GB3452.1-82 | O ring 38.7X3.55 |
| 32 | RS1306.05.015.00 | piston nut |
| 33 | RS11306.05.028 | air case |
| 34 | T05.04 | Fianaed I |
| 35 | T05.05 | Flanaed II |
| 36 | T05.001 | Plug NPTI 1/2 |
| 37 | B05.011 | bolt 11/2-8UNCX221/8 |
| 38 | T05.002 | suck baffle |
| 39 | T05.003 | discharqed baffle |
| 40 | RS11309.05.027 | Gasket rinq39 |
| 41 | N05.001 | bolt 1 1/2-8UNC |
| 42 | GB3452.1-82 | O ring 95X5.3 |
| 43 | GB3452.1-82 | O ring 200X7 |
| 44 | B05.003 | bolt 7/8-9UNCx2.5 |
| 45 | GB3452.1-82 | O ring 185X7 |
| 46 | GB3452.1-82 | O ring 345X7 |
| 47 | N001 | Nut 1-8UNC-2B |
| 48 | B05.004 | Nut 1-8UNCX3.5 |
| 49 | GB4240-84 | steel wire 1.6 |
| 50 | 277 | Glue277 |
| 51 | Q/ZB251 | hub 2 1/4 |
| Part list of Power end assembly | ||
| 1 | GB5628.1-85 | Pipe joint A10 |
| 1 | GBS629.1-85 | Pipe joint A8 |
| 3 | RS11306.06.06.05.00 | Double pipe clamp |
| 4 | GB1527-87 | Copper pipe 10×1956 |
| 5 | GB1527-87 | Copper pipe 8×1956 |
| 6 | RS11309.06.001 | support seat |
| 7 | washer | |
| 8 | T06.001 | joint NPT 1/4-NPT 1/4 |
| 9 | Y60-Z | Gauge 0-0.6Mpa NPT 1/4 |
| 11 | 2SGear oii pump | |
| 11 | 609 or 680 | Setting glue |
| 12 | GB1527-87 | Coper pipe 8X1245 |
| 13 | RS11309.06.02.00 | pipe clamp 12 |
| 14 | GB1527-87 | Coper pipe 8X813 |
| 15 | RS11306.06.02.00 | pipe damp 8 |
| 16 | RS11309.06.03 | bean |
| 17 | JB/ZQ4410-86 | right angle joint A8 |
| 18 | B.06.001 | Bolt 1/4-20uncX 3/4 |
| 19 | GB93-87 | Spring washer 6 |
| 20 | GB1527-87 | Copper pipe 10×838 |
| 21 | RS11306.06.004 | Seat III |
| 22 | T06.003 | Elbow 90 NPT 1/4-NPT3/8 |
| 23 | GB1527-87 | Coper pipe 8X762 |
| 24 | GB1527-87 | Coper pipe 8X1016 |
| 25 | GB1527-87 | Coper pipe 8X1194 |
| 26 | GB1527-87 | Coper pipe 8X508 |
| 27 | GB1S27-87 | Coper pipe 8X229 |
| 28 | T06.002 | Pluq NPT1/4″ |
| 29 | GB1527-87 | Coper pipe 8X915 |
| 30 | JB/ZQ4410-86 | right angle joint A10 |
| 31 | RS11309.06.004 | joint 45 |
| 32 | JB/ZQ4408-86 | Right angle joint A12 |
| 33 | GB1527-87 | Coper pipe12x305 |
| 34 | RS11309.06.05.00 | Pipe clamp 10 |
| 35 | GB1527-87 | pipe clamp 12X610 |
| 36 | RS11306.06.13.00 | fuel filter |
| 37 | JB/ZQ4408-86 | right angle joint A16 |
| 38 | GB1527-87 | Coper pipe 16X331 |
| 39 | GB1527-87 | Coper pipe 16X686 |
| 40 | RS11306.06.007 | Seat III |
| 41 | JB/ZQ4408-86 | right angle joint A8 |
| 42 | YYFJ-L20 | overflow valve |
| 43 | JB/ZQ4410-86 | right angle joint A16 |
| 44 | B.06.002 | Bolt 3/8-16UNC x 1 5/8 |
| 45 | GB93-87 | Spring Washer 10 |
| 46 | RS11306.06.011 | square key |
| 47 | RS11306.06.08.00 | Gear Assy |
| 48 | RS11306.06.09.00 | Pipe clamp II 8 |
| 49 | GB1527-87 | Coper pipe 8X16H |
| 50 | GB1527-87 | Coper pipe 8X2311 |
| 51 | GB1527-87 | Coper pipe 8X305 |
| 52 | JB/ZQ4408-86 | Right angle joint A10 |
| Part list of Spray pump assembly | ||
| Iten | Part No, | Description |
| 1 | RS11309.08.0011/001A | guard cover |
| 2 | RS11309.08.002 | belt pulley |
| 3 | RS11306.08.13.00 | seat |
| 4 | RS11306.08.017 | flange NPT1 1/2 |
| 5 | RS11306.08.003 | 90°elbow joint NPT 2 1/2 |
| 6 | RS11306.08.004 | joint NPT1 1/2 |
| 7 | clamp | |
| 8 | joint NPT1 -G1 | |
| 9 | RS11306.08.011 | Combined pipe |
| 10 | HG4-761 | hose L=750 |
| 11 | RS11306.08.005 | joint NPT2 1/2 |
| 12 | GB/T14626 | 90°elbow joint NPTl 1/2 |
| 13 | RS11309.08.003 | pup jointNPT 2 1/2-NPT 2 1/2 |
| 14 | RS11306.08.20.002 | joint NPT1 |
| 15 | RS11309.08.004 | connect pipe NPT1 |
| 16 | RS11309.08.05.00 | water box |
| 17 | RS11309.08.06.00 | Water box head |
| 18 | RS11309.08.007 | joint NPT2 1/2 |
| 19 | Bail valve G1 | |
| 20 | RS11306.08.008 | 90°eibow NPT1 |
| 21 | B.08.001 | screw3/8-16UNCXl |
| 22 | RS11306.08.014 | connection plate |
| 23 | B.08.002 | bolt 5/8-11UNCX1 1/8 |
| 24 | GB93 | spring washerl6 |
| 25 | GB95 | fiat washer 16 |
| 26 | B.08.003 | bdtl/P-13UNCX1 5/8 |
| 27 | GB95 | fiat washer |
| 28 | GB93 | spring washerl2 |
| 29 | B.08.004 | boltl/P-13UNCXP 3/8 |
| 30 | N.08.001 | bolt 1/2-13UNC |
| 31 | RS11306.08.016 | washer |
| 32 | RS1131G8.015 | flange NPT1″ |
| 33 | Spray punp | |
| 34 | RS11306.08.12.00 | support |
| 35 | RS11306.08.019 | welding plate |
| 36 | RS11306.08.20.00 | three way nanifold |
| 37 | GB1171 | V belt A3708 |
| Part list of Discharge five way spool assembly | ||
| 1 | TJJ01 | flange 5 1/8 |
| 2 | RS11309.16.01.00 | five way spool |
| 3 | RS11309.16.002 | 5 1/8 blind flange III |
| 4 | RS11309.16.003 | 5 1/8 blind flange II |
| 5 | RS11309.16.04.00 | filter pipe |
| 6 | SY5279.3-91 | ring gasket |
| 7 | B.16.001 | bolt 11/2-12UNF-8UN |
| 8 | N05.001 | nutl 1/2-8UNC |
| 9 | RS11309.16.005 | elbow NPT 2 |
| 10 | RS11309.09.010 | sealer |
| 11 | RS11309.16.006 | gauge joint NPT 1 1/P |
| 12 | T.05.001 | pluge NPT 1 1/2 |
| 13 | RS11309.16.007 | flange |
| 14 | B.16.002 | bolt 5/8-10UNCX2.5 |
| 15 | GB93 | Spring washer 20 |
| 16 | glue | |
| Part list of Dampener pulsation assembly | ||
| 1 | SY5279.3-91 | Gasket R39 |
| 2 | RS11306.19.001 | Bottom plug |
| 3 | Gas bag | |
| 4 | RS11306.19..02.001 | Body |
| 5 | RS11306.19.003 | Cover |
| 6 | RS11306.19.004 | T-Joint NPT 1/4 |
| 7 | RS11306.19.004 | Joint |
| 8 | RS11306.19.06.00 | Pressure gauge cover asse |
| 9 | PJC1-L8 | Exhaust Valve |
| 10 | Y-60 | Pressure gauge 0-25Mpa |
| 11 | GB/T1230 | Washer 14 |
| 12 | JZR3-L8 | Right-angle break valve |
| 13 | B.19.001 | Bolt 1 1/2-12UNF-8UN |
| 14 | N.05.001 | Nut 1 1/2-8UN-2B |
| 15 | B.19.002 | Bolt 1 1/4-12UNF-8UN |
| 16 | N.19.001 | Nut 1 1/4-8un-2b |
| RS-F1600/1300 Hose assembly of dampener pulsation | ||
| 1 | RS11306.25.6.10.001 | Nut |
| 2 | RS11306.25.6.10.002 | Seale Joint |
| 3 | RS11306.25.6.10.003 | Type C soft pipe M14x1.5-d=6.2 |
| 4 | RS11306.25.6.10.003 | Joint |
| 5 | RS11306.25.6.10.004 | Sealer |
| 6 | RS11306.25.6.10.005 | Plug |